Toyota Tacoma 2015-2018 Service Manual: Open or Short in Front Speed Sensor RH Circuit (C1405,C1406)

Toyota Tacoma 2015-2018 Service Manual: Open or Short in Front Speed Sensor RH Circuit (C1405,C1406)

DESCRIPTION

Refer to DTCs C1401 and C1402 (See page).

DTC Code

DTC Detection Condition

Trouble Area

C1405

C1406

Either condition is met:

  1. An open in the speed sensor signal circuit continues for 0.5 seconds or more.
  2. With the IG1 terminal voltage at 9.5 V or higher, the sensor power supply voltage decreases for 0.5 seconds or more.
  • Front speed sensor RH/LH
  • Skid control sensor wire
  • Speed sensor circuit
  • Skid control ECU (master cylinder solenoid)

HINT:

  • DTC C1405 is for the front speed sensor RH.
  • DTC C1406 is for the front speed sensor LH.

WIRING DIAGRAM CAUTION / NOTICE / HINT

CAUTION / NOTICE / HINT

NOTICE:

  • When replacing the skid control ECU (master cylinder solenoid), perform calibration (See page).Check the speed sensor signal after replacement (See page).
  • Check the speed sensor signal after replacement (See page ).

PROCEDURE

1.

CHECK HARNESS AND CONNECTOR (MOMENTARY INTERRUPTION)

(a) Using the Techstream, check for any momentary interruption in the wire harness and connector corresponding to the DTC (See page). ).

ABS/VSC/TRAC

Tester Display

Measurement Item/Range

Normal Condition

Diagnostic Note

FR Speed Open

Front speed sensor RH open detection/ Error or Normal

Normal

-

FL Speed Open

Front speed sensor LH open detection/ Error or Normal

Normal

-

OK:

Normal (there are no momentary interruptions).

HINT:

Perform the above inspection before removing the sensor and connector.

NG

GO TO STEP 4

OK

2.

READ VALUE USING TECHSTREAM (FRONT SPEED SENSOR)

NG

GO TO STEP 4

OK

3.

RECONFIRM DTC

(a) Clear the DTCs (See page).(b) Turn the ignition switch off.).

(b) Turn the ignition switch off.

(c) Start the engine.

(d) Drive the vehicle at a speed of 40 km/h (25 mph) or more for at least 60 seconds.

(e) Check if the same DTC is output (See page).Result).

Result

Result

Proceed to

DTCs C1405 and C1406 are not output

A

DTCs C1405 and/or C1406 are output

B

A

USE SIMULATION METHOD TO CHECK

B

REPLACE MASTER CYLINDER SOLENOID

4.

INSPECT SKID CONTROL SENSOR WIRE

(a) Remove the skid control sensor wire.

(b) Measure the resistance according to the value(s) in the table below.

Standard Resistance:

RH

Tester Connection

Condition

Specified Condition

Va1-1 - S4-1 (FR-)

Always

Below 1 Ω

Va1-2 - S4-2 (FR+)

Always

Below 1 Ω

Va1-1 - Va1-2

Always

10 kΩ or higher

LH

Tester Connection

Condition

Specified Condition

Wa1-1 - S3-1 (FL-)

Always

Below 1 Ω

Wa1-2 - S3-2 (FL+)

Always

Below 1 Ω

Wa1-1 - Wa1-2

Always

10 kΩ or higher

Text in Illustration

*1

Skid Control Sensor Wire

*a

RH

*b

LH

NG

REPLACE SKID CONTROL SENSOR WIRE

OK

5.

CHECK HARNESS AND CONNECTOR (SKID CONTROL ECU - FRONT SPEED SENSOR)

(a) Install the skid control sensor wire.

(b) Disconnect the S1 skid control ECU (master cylinder solenoid) connector.

(c) Disconnect the S4 and/or S3 front speed sensor connector.

(d) Measure the resistance according to the value(s) in the table below.

Standard Resistance:

RH

Tester Connection

Condition

Specified Condition

S1-3 (FR+) - S4-2 (FR+)

Always

Below 1 Ω

S1-3 (FR+) - Body ground

Always

10 kΩ or higher

S1-17 (FR-) - S4-1 (FR-)

Always

Below 1 Ω

S1-17 (FR-) - Body ground

Always

10 kΩ or higher

LH

Tester Connection

Condition

Specified Condition

S1-18 (FL+) - S3-2 (FL+)

Always

Below 1 Ω

S1-18 (FL+) - Body ground

Always

10 kΩ or higher

S1-4 (FL-) - S3-1 (FL-)

Always

Below 1 Ω

S1-4 (FL-) - Body ground

Always

10 kΩ or higher

NG

REPAIR OR REPLACE HARNESS OR CONNECTOR

OK

6.

INSPECT SKID CONTROL ECU (FR+, FL+ TERMINAL)

(a) Disconnect the S4 and/or S3 front speed sensor connector.

(b) Connect the S1 skid control ECU (master cylinder solenoid) connector.

(c) Measure the voltage according to the value(s) in the table below.

Related news

  • Toyota RAV4 Service Manual: Front brake
  • Mercedes-Benz E-Class: Coolant
  • Toyota Sienna 2010-2018 Owners Manual: General settings
  • Chevrolet Sonic Repair Manual: Seat Adjustment
  • Mazda Mazda6: Convenient Use of the Hands-Free System

  • Toyota Tacoma 2015-2018 Service Manual: Open or Short in Front Speed Sensor RH Circuit (C1405,C1406)

    Toyota Tacoma 2015-2018 Service Manual: Open or Short in Front Speed Sensor RH Circuit (C1405,C1406)

    Toyota Tacoma 2015-2018 Service Manual: Open or Short in Front Speed Sensor RH Circuit (C1405,C1406)

    Toyota Tacoma 2015-2018 Service Manual: Open or Short in Front Speed Sensor RH Circuit (C1405,C1406)

    Toyota Tacoma 2015-2018 Service Manual: Open or Short in Front Speed Sensor RH Circuit (C1405,C1406)

    Toyota Tacoma 2015-2018 Service Manual: Open or Short in Front Speed Sensor RH Circuit (C1405,C1406)

    Toyota Tacoma 2015-2018 Service Manual: Open or Short in Front Speed Sensor RH Circuit (C1405,C1406)

    Toyota Tacoma 2015-2018 Service Manual: Open or Short in Front Speed Sensor RH Circuit (C1405,C1406)

    Toyota Tacoma 2015-2018 Service Manual: Open or Short in Front Speed Sensor RH Circuit (C1405,C1406)

    Toyota Tacoma 2015-2018 Service Manual: Open or Short in Front Speed Sensor RH Circuit (C1405,C1406)

    Toyota Tacoma 2015-2018 Service Manual: Open or Short in Front Speed Sensor RH Circuit (C1405,C1406)

    Toyota Tacoma 2015-2018 Service Manual: Open or Short in Front Speed Sensor RH Circuit (C1405,C1406)

    Toyota Tacoma 2015-2018 Service Manual: Open or Short in Front Speed Sensor RH Circuit (C1405,C1406)

    Toyota Tacoma 2015-2018 Service Manual: Open or Short in Front Speed Sensor RH Circuit (C1405,C1406)

    Toyota Tacoma 2015-2018 Service Manual: Open or Short in Front Speed Sensor RH Circuit (C1405,C1406)

    Toyota Tacoma 2015-2018 Service Manual: Open or Short in Front Speed Sensor RH Circuit (C1405,C1406)

    Toyota Tacoma 2015-2018 Service Manual: Open or Short in Front Speed Sensor RH Circuit (C1405,C1406)

    Toyota Tacoma 2015-2018 Service Manual: Open or Short in Front Speed Sensor RH Circuit (C1405,C1406)

    Toyota Tacoma 2015-2018 Service Manual: Open or Short in Front Speed Sensor RH Circuit (C1405,C1406)

    Toyota Tacoma 2015-2018 Service Manual: Open or Short in Front Speed Sensor RH Circuit (C1405,C1406)

    Toyota Tacoma 2015-2018 Service Manual: Open or Short in Front Speed Sensor RH Circuit (C1405,C1406)